97 SSEi Tuneup

[mastersj]

I am in dire need of a tuneup but do not trust anyone around here including the local Chevy dealer who RECENTLY I went to for an oil change and did not tighten the oil filter. I headed off on a 800 mile trip right after the oil change only to have a huge puddle under car the next morning.

What do I need to tune my baby up the best ?

Plugs, Wires I know this much but what else can I do as she has 271,000 miles on her RUNS strong and hard but needs some loving ?


Thank You,

John

[Jfridge92]

From our very own Ed (00beast)

• 1987-2005 Bonneville / Buick 3800 Maintenance List
  
  Grease: Ball Joints, Tie Rods Every 8-10k ( Green Grease or Amsoil Grease recommended)
  Air Filter Every 15k (Amsoil EaA, Purolator PureONE)
  PCV Valve Every 30k
  MAF Sensor Element Cleaning/TB Cleaning Every 50k viewtopic.php?f=48&t=1661
  Fuel Filter Every 15-25k (Purolator, AC Delco, WIX) http://www.pontiacbonnevilleclub.com/fo ... 45&t=23215
  Spark Plugs Every 30-50k (NGK TR55, AC Delco 41-101 or Autolite 605) (Never Bosch)
  Ignition Wires Every 30-50k (Napa Belden, AC Delco, Autolite Pro, NGK) (Never Taylor or Bosch)
  Oil & Filter Every 5-6k or Every 6 months (Valvoline SYNPower, Pennzoil Platinum, or Amsoil )(Mobil1, Purolator PureONE, Amsoil EaO, K&N or WIX) (Never Fram) viewtopic.php?f=45&t=214
  *Conventional Oil Every 3k/3 months(API SM/SN rating) (WIX (Napa), Delco or Purolator filter)
  Tires: Check Inflation Pressure & Visually Inspect Monthly Rotate Every 6-8,000 Miles
  Transmission Flush or Pan Drop Every 15-20k (Always make sure filter is changed when flushed) viewtopic.php?f=45&t=10193
  Cooling System Flush Every 25-50k or 3-5 Years (Peak or Prestone Mixes-With-Any Coolant Only) (Never Dexcool)
  Oxygen Sensor Every 80-100k (30k for non-heated) (AC Delco or Denso) (Absolutely never Bosch) viewtopic.php?f=48&t=794
  Accessory Belt Inspect every 15k, replace every 100k, or as needed
  Cabin Air Filter Inspect and Replace every 15k, or as needed in dusty conditions. (Note: 00+ Only) viewtopic.php?f=45&t=13626
  Evap Core Cleaning Whenever Needed (Note: 99 and older only) viewtopic.php?f=45&t=2432
  Brake Fluid Flush 3yr/50k
  Power Steering Fluid Replacement/Flush Every 100k or 5 years
  
  *Special Considerations*
  All Series II/III 3800's RPO's: L36, L26, L67 & L32, especially important on vehicles factory installed with orange Havoline Dexcool Antifreeze/Coolant: http://www.dex-cool.net/
  Lower Intake Manifold Gasket Replacement, every 80-100k (ignorance of this can allow coolant to enter your engine oil, this happening can cause irreversible lower engine damage, requiring replacement of subject engine)
  
  Series II, Naturally Aspirated, RPO:L36:
  Upper Intake Manifold Plenum Replacement, Every 80-100k (ignorance of this can allow coolant to enter your intake manifold, possible damage to occur can be hydrolock, irreversible damage to emissions devices, misfires, etc. Most times, engine replacement is required if ignored long enough.) viewtopic.php?f=53&t=1061
  
  Series I, II, III RPO Code L67 & L32:
  Change Supercharger Oil; Every 30-50k. (Intense Racing or GM Dealer) viewtopic.php?f=56&t=1690
  Supercharger Belt; Inspect Every 15k, Replace Every 100k or as needed.

1/25/2013 by 00Beast

[00Beast]

Joe, next time, quote my post in the thread, then copy it with all the link codes, etc.

[Jfridge92]

I meant to do that Ed, but I was doing it on my mobile at work hahaha. I'll fix it real quick

[mastersj]

Guys,

THANK YOU very much.

This wknd my baby is getting the royal treatment

[mastersj]

Has anyone changed the Intake Manifold gasket on their Super Charged Bonneville ?

What is involved in doing so ?